德國Rexroth電磁閥，REXROTH電磁閥，德國力士樂電磁閥

電磁閥在我們的生產中應用十分廣泛，我們在對生產的維護中一定遇見過不少有關電磁閥的問題，也處理過各種各樣的故障，大家也一定積累了不少有關電磁閥故障處理的經驗，而我在維護中處理電磁閥故障相對別的儀控故障相對較少，現在我就這個問題一起和大家討論，渴望從大家那里學習更多的經驗，共同提高。
我們先對電磁閥有個初步的認識，電磁閥是由電磁線圈和磁芯組成，是包含一個或幾個孔的閥體。當線圈通電或斷電時，磁芯的運轉將導致流體通過閥體或被切斷，以達到改變流體方向的目的。電磁閥的電磁部件由固定鐵芯、動鐵芯、線圈等部件組成；閥體部分由滑閥芯、滑閥套、彈簧底座等組成。電磁線圈被直接安裝在閥體上，閥體被封閉在密封管中，構成一個簡潔、緊湊的組合。我們在生產中常用的電磁閥有二位三通、二位四通、二位五通等。這里先說說二位的含義：對于電磁閥來說就是帶電和失電，對于所控制的閥門來說就是開和關。
我們制氧機儀控系統中，二位三通電磁閥用的最多，它在生產中可用來接通或切斷氣 源，從而對氣動控制膜頭氣路進行切換。
德國Rexroth電磁閥，REXROTH電磁閥，德國力士樂電磁閥它由閥體、閥罩、電磁組件、彈簧及密封結構等部件組成，動鐵芯底部的密封塊借助彈簧的壓力將閥體進氣口關閉。通電后，電磁鐵吸合，動鐵芯上部帶彈簧的密封塊把排氣口關閉，氣流從進氣口進入膜頭，起到控制作用。當失電時，電磁力消失，動鐵芯在彈簧力作用下離開固定鐵芯，向下移動，將排氣口打開，堵住進氣口，膜頭氣流經排氣口排出，膜片恢復原來位置。在我們的制氧設備中，在透平膨脹機進口薄膜調節閥的緊急切斷等處有應用。
四通電磁閥在我們的生產中應用也很多，其工作原理如下：
當有電流通過線圈時，產生勵磁作用，固定鐵芯吸合動鐵芯，動鐵芯帶動滑閥芯并壓縮彈簧，改變了滑閥芯的位置，從而改變了流體的方向。當線圈失電時，依靠彈簧的彈力推動滑閥芯，頂回動鐵芯，使流體按原來的方向流動。在我們制氧生產中，分子篩切換系統強制閥的開關就是通過二位四通電磁閥來控制的，氣流分別供至強制閥的活塞兩端。從而來控制強制閥的啟閉。
電磁閥的故障將直接影響到切換閥和調節閥的動作，常見的故障有電磁閥不動作，應從以下幾方面排查：
（1）電磁閥接線頭松動或線頭脫落，電磁閥不得電，可緊固線頭。
（2）電磁閥線圈燒壞，可拆下電磁閥的接線，用萬用表測量，如果開路，則電磁閥線圈燒壞。原因有線圈受潮，引起絕緣不好而漏磁，造成線圈內電流過大而燒毀，因此要防止雨水進入電磁閥。此外，彈簧過硬，反作用力過大，線圈匝數太少，吸力不夠也可使得線圈燒毀。緊急處理時，可將線圈上的手動按鈕由正常工作時的“0”位打到“1”位，使得閥打開。
（3）電磁閥卡住。電磁閥的滑閥套與閥芯的配合間隙很小（小于0.008mm），一般都是單件裝配，當有機械雜質帶入或潤滑油太少時，很容易卡住。處理方法可用鋼絲從頭部小孔捅入，使其彈回。根本的解決方法是要將電磁閥拆下，取出閥芯及閥芯套，用CCI4清洗，使得閥芯在閥套內動作靈活。拆卸時應注意各部件的裝配順序及外部接線位置，以便重新裝配及接線正確，還要檢查油霧器噴油孔是否堵塞，潤滑油是否足夠。
（4）漏氣。漏氣會造成空氣壓力不足，使得強制閥的啟閉困難，原因是密封墊片損壞或滑閥磨損而造成幾個空腔竄氣。
在處理切換系統的電磁閥故障時，應選擇適當?shù)臅r機， 等該電磁閥處于失電時進行處理，若在一個切換間隙內處理不完，可將切換系統暫停，從容處理。

德國Rexroth電磁閥，REXROTH電磁閥，德國力士樂電磁閥

R900701362 PV7-1X/40-45RE37KD0-16
R900700384 PV7-1X/40-45RE37MW0-16WH
R900618143 PV7-2X/20-20RA01MA0-10-A416
R900598753 PV7-1X/10-14RE01MC3-16
R900593330 PV7-1X/40-45RE37MD0-16
R900592237 PV7-1X/16-20RE01MC3-16
R900590087 PV7-1X/40-45RE37MC3-16
R900586235 PV7-1X/25-30RE01MC3-16
R900580384 PV7-1X/40-45RE37MC0-16
R900580383 PV7-1X/25-30RE01MC0-16
R900580382 PV7-1X/16-20RE01MC0-16
R900580381 PV7-1X/10-14RE01MC0-16
R900576487 PV7-1X/25-45RE01MC5-08WH
R900574560 PV7-1X/63-94RE07MD0-08
R900573212 PV7-1X/16-20RE01MD0-16-A234
R900571305 PV7-1X/63-71RE07KC0-16
R900568873 PV7-1X/100-150RE07KC0-08
R900568833 PV7-1X/25-45RE01MD0-08
R900564746 PV7-1X/06-10RA01MA3-10
R900563233 PV7-1X/06-10RA01MA0-10
R900562475 PV7-1X/25-30RE01KC0-16
R900561857 PV7-1X/06-10RA01MA0-05
R900561846 PV7-1X/100-150RE07MC0-08
R900561581 PV7-1X/40-71RE37MC3-08
R900560916 PV7-1X/10-14RE01KC0-16
R900560659 PV7-1X/63-94RE07MC0-08
R900560658 PV7-1X/16-30RE01MD0-08
R900560629 PV7-1X/100-150RE07MC5-08
R900556803 PV7-1X/100-118RE07MC5-16WH
R900553692 PV7-1X/63-71RE07MC5-16WG
R900553588 PV7-1X/40-45RE37MC5-16WH
R900551273 PV7-1X/25-45RE01MC7-08
R900551051 ABHAG-0160S43/PV7-16-30/112M/S /S02G781A
R900548512 PV7-1X/10-14RE01MD0-16-A234
R900546887 PV7-1X/63-71RE07KC3-16
R900546886 PV7-1X/25-30RE01KC3-16
R900539886 PV7-1X/40-71RE37MD0-08
R900538525 PV7-1X/25-45RE01MC3-08
R900538125 PV7-1X/10-20RE01MC3-10
R900537419 PV7-1X/10-14RE01MN0-16
R900534508 PV7-1X/25-45RE01MC0-08
R900534412 PV7-1X/16-20RE01MC7-16
R900534143 PV7-1X/10-20RE01MC0-10
R900533851 PV7-1X/10-14RE01MC0-16-A184
R900533637 PV7-1X/100-118RE07MC7-16
R900533582 PV7-1X/16-30RE01MC0-08
R900533296 PV7-1X/16-30RE01MC3-08
R900532770 PV7-1X/100-118RE07MD0-16
R900535588 PV7-1X/40-71RE37MC0-08
R900535532 PV7-1X/25-45RE01MC5-08
R900523597 PV7-1X/40-45RE37KC0-16
R900520787 PV7-1X/10-14RE01MD5-16
R900520401 PV7-1X/10-14RE01MC5-16
R900519094 PV7-1X/63-71RE07MD0-16
R900518218 PV7-1X/63-71RE07MC5-16
R900517795 PV7-1X/16-20RE01MC0-16-A184
R900517464 PV7-1X/25-30RE01MC5-16
R900516546 PV7-1X/100-118RE07MC5-16
R900511986 PV7-1X/63-71RE07MC3-16
R900511215 PV7-1X/100-118RE07MC3-16
R900509506 PV7-1X/25-30RE01MD0-16
R900509274 PV7-1X/16-20RE01MD0-16
R900509053 PV7-1X/10-14RE01MC7-16
R900506809 PV7-1X/100-118RE07MC0-16
R900506808 PV7-1X/63-71RE07MC0-16
R900506473 PV7-1X/16-20RE01MC5-16
R900504653 PV7-1X/10-14RE01MD0-16
R900502277 PV7-1X/40-45RE37MC5-16
R901134661 PV7-1X/16-20RE01MD6-16
R901133981 PV7-1X/63-71RE07MC3-06-A460
R901129340 PV7-1X/100-118RE07MW6-16WH
R901100271 ABAPG-PV7/40-45C0+06-10A0/160L-4-B1/SE
R901083391 ABHPG-PV7/16-20C0+PF-005/132M-4-B1/LF
R901083371 ABAPG-PV7/63-71C5WH+GH2-008/200L-4-N0/E&
R901081778 PV7-1X/06-14RA01MA0-10-A452
R901072539 ABPBG-PV7/100-118C0+GF3-40+GF2-08/BG160*
R901065655 PV7-1X/06-10RA01KA0-05
R901064326 PV7-1X/40-55RE37MC0-08-A449
R901062106 ABHPG-PV7/40-45C0/132S-4-B0/S *
R901062065 ABHPG-PV7/06-10A0/100L-4-A1K/L VEM
R901061279 PV7-1X/100-118RE07MW0-16WG
R901059512 PV7-1X/40-71RE37MW0-08WH
R901055473 PV7-1X/40-45RE37MW0-16WG
R901054762 ABHPG-PV7/10-20C0+10-20C0/100L-4-A0/S
R901054761 ABHPG-PV7/06-10A0/90S-4-A0/S
R901049367 ABHAG-0160S43/PV7-25/132M/NTW/005C068A
R901049299 ABAPG-PV7-118D0+10SO18DRG/225S-4-B0/SEFR
R901047776 PV7-1X/40-45RE37MC0-16-A446
R901047606 PV7-1X/06-10RA01KA0-10
R901043560 PV7-1X/10-20RE01MW0-10WH
R901041243 ABHAG-0160SS0/PV7-25/160M/AB1A041A
R901040726 ABHPG-PV7/10-14C5/132S-4-B0/S
R901032005 PV7-1X/40-45RE37MC7-16WG
R901030877 ABHPG-PV7/16-20C0/132M-4-B1/L
R901026649 PV7-1X/06-10RA01MA0-10-A441
R901022287 PV7-1X/25-30RE01MN0-16
R901021722 PV7-1X/63-71RE07KW0-16WG
R901017159 PV7-1X/63-71RE07MW0-16WH
R901012191 ABVPG-PV7/10-20+06-14A399/112M-4-B0/S
R901005498 ABVPG-PV7/100+100+ 40/ /004 A
R901003246 ABSAG-0400S40-W/PV740-45/180M/012B764-A1
R900979440 PV7-1X/40-45RE37MW0-16
R900978121 PV7-1X/06-10RE01MA3-10
R900976176 PV7-1X/25-45RE01MN0-08
R900976100 PV7-1X/63-71RE07MC6-16
R900973308 PV7-1X/06-14RA01MA0-07-A399
R900973306 PV7-1X/06-14RA01MA0-04-A399
R900964375 PV7-1X/06-14RE01MA3-07
R900963916 PV7-1X/06-10RA01MA0-10-A501
R900961521 PV7-1X/100-118RE07MC6-16
R900959317 PV7-1X/40-45RE37MC7-16
R900958306 PV7-1X/06-14RE01MA0-07
R900954137 PV7-1X/40-45RE37MC6-16
R900952282 PV7-1X/06-14RA01MA3-07
R900950955 PV7-2X/20-25RA01MA0-10
R900950954 PV7-2X/20-25RA01MA0-05
R900950953 PV7-2X/20-20RA01MA0-10
R900950952 PV7-2X/20-20RA01MA0-05
R900950419 PV7-1X/100-118RE07MD0-16-A234
R900950061 PV7-1X/100-118RE07MC5-16WG
R900949187 PV7-1X/100-118RE07MD6-16
R900948299 PV7-1X/100-150RE07MC5-08WH
R900946174 PV7-1X/40-45RE37MC0-16-A276
R900942455 PV7-1X/63-71RE07MC5-16WH
R900941073 PV7-1X/10-14RE01MC0-16-A268
R900941071 PV7-1X/10-14RE01MC0-16-A267
R900939159 PV7-1X/16-20RE01MN0-16
R900937407 PV7-1X/100-150RE07KD0-08
R900936326 PV7-1X/06-10RE01MA0-05
R900935443 PV7-1X/40-45RE37MC3-16-A184
R900933324 PV7-1X/10-14RE01MC5-16WH
R900933323 PV7-1X/25-30RE01MC5-16WH
R900931321 PV7-1X/06-14RA01MA0-04-A257
R900930060 PV7-1X/10-14RE01MC0-16-A202
R900928704 PV7-1X/100-118RE07MN0-16
R900926429 PV7-1X/16-20RE01MC5-16 WH
R900925956 PV7-1X/63-71RE07MD0-16-A234
R900922602 PV7-1X/40-45RE37MD0-16-A234
R900920233 PV7-1X/16-20RE01MC0-16-A17
R900919237 PV7-1X/06-14RA01MA0-07
R900919235 PV7-1X/06-14RA01MA0-04
R900916201 PV7-1X/10-20RE01KC0-10
R900915470 PV7-1X/100-150RE07MD0-08
R900914685 ABAPG-PV7/63C0-14/180M-4-B0/SE-A
R900914676 ABAPG-PV7/40C0-16/160L-4-B1/SE-A
R900914674 ABAPG-PV7/40C0-16/132M-4-B1/SE-A
R900910480 PV7-1X/63-71RE07MD5-16
R900910479 PV7-1X/100-150RE07MD5-08
R900910016 PV7-1X/40-45RE37MC5-16WG
R900906584 PV7-1X/10-20RE01MD0-10
R900903108 PV7-1X/06-10RE01MA0-10
R900901155 ABAPG-PV7/100C0-14/180L-4-B1/SEMFR-A
R900901153 ABAPG-PV7/100C0-14/160L-4-B1/SEMFR-A
R900901149 ABAPG-PV7/63C0-14/180M-4-B0/SEMFR-A
R900901105 ABAPG-PV7/40C0-16/160L-4-B1/SEMR-A
R900891727 DICHTUNGSSATZ V3-4X/12+PV7-1X/06V
R900891726 DICHTUNGSSATZ V3-4X/12+PV7-1X/06M
R900891725 DICHTUNGSSATZ V3-4X/25+PV7-1X/20V
R900891724 DICHTUNGSSATZ V3-4X/25+PV7-1X/20M
R900891704 DICHTUNGSSATZ PV7-1X/10M
R900891703 DICHTUNGSSATZ PV7-1X/16M
R900891702 DICHTUNGSSATZ PV7-1X/25M
R900891701 DICHTUNGSSATZ PV7-1X/40M
R900891700 DICHTUNGSSATZ PV7-1X/63M
R900891699 DICHTUNGSSATZ PV7-1X/100M
R900874811 DICHTUNGSSATZ PV7-2X/20
R900782907 ABHPG-PV7/25-45C0-08/112M-4-B0/S
R900780016 PV7-1X/25-45RE01MW0-08WH
R900772792 PV7-1X/10-14RE01MW0-16
R900772699 ABHPG-013-PV7-RKD-03
R900772698 ABHPG-013-PV7-RKD-02
R900772687 ABAPG-PV7/100-150C0+GF2-011/160M-4-B0/SD
R900771631 PV7-1X/100-118RE07MD0-16-A427
R900770527 ABHPG-PV7/10-14C0/112M-4-B0/J
R900768658 PV7-1X/25-30RE01MW0-16
R900763234 ABKAG-60AL9/PV7-10/90L-4-A1/NL/012B605A1
R900761807 PV7-1X/100-150RE07MC5-08WG
R900758432 PV7-2X/20-20RE01MA3-10
R900755261 PV7-2X/20-20RA01MA3-05
R900751356 PV7-1X/25-45RE01MC7-08WG
R900750169 PV7-1X/63-71RE07MD6-16
R900749846 PV7-2X/20-20RA01MA3-10
R900744715 PV7-1X/63-71RE07MN0-16
R900744495 PV7-1X/25-30RE01MW0-16WH
R900741427 PV7-2X/20-25RA01MA3-05
R900740824 PV7-1X/100-118RE07MW0-16WH
R900738663 PV7-1X/10-20RE01MC5-10WG
R900733271 PV7-1X/63-71RE07MW0-16
R900729468 PV7-1X/10-14RE01KD0-16
R900720730 PV7-1X/63-71RE07MC0-16-A234
R900720285 ABAPG-PV7/63-71C0-16/200L-4-B0K/SE-A
R900718547 ABHPG-PV7/20-25-0-10/112M-4-B0/S-A
R900711250 PV7-1X/40-71RE37MC5-08WH
R900707375 PV7-2X/20-25RE01MA0-10
R900707373 PV7-2X/20-20RE01MA0-10
R900707372 PV7-2X/20-20RE01MA0-05
R900705106 PV7-1X/63-71RE07MC7-16WH
R900704549 PV7-2X/20-25RA01MA3-10
R900919237 PV7-1X/06-14RA01MA0-07
R900910016 PV7-1X/40-45RE37MC5-16WG
R900247239 PV7-1X/10-20RE01MC5-10WH
R900245924 PV7-1X/16-30RE01MC5-08WH
R900891703 SEAL KIT PV7-1X/16M
R900598753 PV7-1X/10-14RE01MC3-16
R900590087 PV7-1X/40-45RE37MC3-16
R900580384 PV7-1X/40-45RE37MC0-16
R900580383 PV7-1X/25-30RE01MC0-16
R900580382 PV7-1X/16-20RE01MC0-16
R900580381 PV7-1X/10-14RE01MC0-16
R900573212 PV7-1X/16-20RE01MD0-16-A234
R900563233 PV7-1X/06-10RA01MA0-10
R900560659 PV7-1X/63-94RE07MC0-08
R900535588 PV7-1X/40-71RE37MC0-08
R900534143 PV7-1X/10-20RE01MC0-10
R900533582 PV7-1X/16-30RE01MC0-08
R900506809 PV7-1X/100-118RE07MC0-16
R900506808 PV7-1X/63-71RE07MC0-16
R900504653 PV7-1X/10-14RE01MD0-16
513800437 0513R15A7VPV72SM21JSB05